4-32.
STARTER ASSEMBLY. (cont)
c.
Insta llation.
(cont)
C A U T I O N
To prevent
cover and to
application,
be used when
jamnut (5).
damage
to solenoid
ensure proper torque
a backup wrench must
torque is applied to
(2) Connect wiring to starter.
When attaching positive battery cable
(6) to starter terminal, use backup
wrench on bottom nut while applying
torque to jamnut (5).
Torque jamnut
(5) to 50-70 inch pounds (5.7-7.9 Nm).
(3) Install engine housing access
cover
and
secure
with
turnlock
fasteners.
(4) Connect battery cable plug
connector to battery.
4-33. CURRENT
SHUNT
(20
AMP).
Maintenance of the 20 amp current shunt
(figure 4-21) consists of inspection
and replacement.
a.
Inspection.
(1) Remove power cable from cable
support assembly.
W A R N I N G
To prevent
battery is
Performing
injury,
ensure that
disconnected before
maintenance
on
electrical components.
(2) Disconnect battery cable plug
connector.
(3) Unlatch and open inlet air
housing access door.
Secure in open
position.
ARMY
TM 5-6115-612-12
MARINE CORPS TM 6115-12/7
AIR FORCE
TO 35C2-3-471-1
NAVY
AG-320B0-0MM-000
(4) Check
mounting
points of
current shunt.
Tighten securely, if
loose.
(5) Check input and output lugs
for discoloration.
Discoloration of
lugs indicates loosening of connections
during operation.
Tighten any loose
connections.
(6) Inspect for dirt on current
shunt.
If dirt is found, first try
cleaning
with
compressed
air.
If
unsuccessful,
clean
with
electrical
grade solvent.
(7) Check current shunt for phy-
sical damage.
If damage is found,
replace shunt.
(8) Close
and
securely
latch
inlet air housing access door.
(9) Connect
battery
plug
connector.
(10) Stow power cable on cable
support assembly.
b. Removal.
(1) Remove
support assembly.
power cable from cable
WARNING
To prevent injury, ensure that
battery is
disconnected before
performing
maintenance
on
electrical components.
(2) Disconnect battery cable plug
connector.
(3) From terminal
(1)
figure 4-21
washer (3), and
wire U111A18.
C, remove screw
),
lockwasher (2),
terminal lug (4) of
4-81
