ARMY TM5-6115-612-12
NAVY AG-320B0-0MM-000
Section V. PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS)
4-9. GENERAL. To ensure that the generator set is
ready for operation at all times, It must be Inspected
systematically so defects may be discovered and
corrected before they result In serious damage or failure
Defects discovered during operation of the unit, such as
minor oil leaks or burned out lights, shall be noted for
future correction Stop operation immediately If a
deficiency is noted, such as abnormal noise, excessive
vibration, fuel leaks, or smoke, that would Indicate
equipment damage. All deficiencies shall be recorded
on the applicable form together with the
corrective action taken Air Force users shall refer to the
applicable Inspection manuals and work card sets in TO
35C2-3 Series for periodic requirements Marine Corps
users shall refer to the current Issue of TM 11275 15 1
Table 4 1 provides a list of preventive maintenance
checks ;and services (PMCS) that shall be performed by
organizational maintenance personnel at weekly monthly
and semi annual Intervals The Item numbers are listed
consecutively and Indicate the sequence of performance
Table 4-1 Preventive Maintenance Checks and Services
W -
Weekly (40 hours)
Total M/’H: 1 0
Interval
M -
Monthly (100 hours)
Total M/H: 7 1
S -
Semiannual (500 hours)
Total M/H: 4 3
Organization
Work
W
M
S
Inspection procedures
M H
1
BATTERY AND CABLE
Service battery In accordance with paragraph 4 27
Clean cable connections In accordance with paragraph 4-26b
0 5
2
LUBRICATION LINES AND FITTINGS
Inspect lubrication lines and fittings In accordance with
paragraph 4-53a
0 2
3
GEARBOX ASSEMBLY AND GEARBOX HOUSING
Inspect gearbox assembly and gearbox housing in accordance
with paragraphs 4-60c and 4-62c
0 1
4
COMBUSTOR HOUSING AND COMPRESSOR INLET HIOUSING
Inspect combustor housing and compressor inlet housing
in accordance with paragraphs 4 58c and 4 59c
0 1
5
INDICATOR LIGHTS AND SOCKETS
Test indicator lights and sockets in accordance with
paragraph 4-73a
() 1
416 Change 6
